Results 1 to 10 of 10

Thread: MEP-802a electrical diagram

  1. #1
    Colonel
    Join Date
    Feb 2013
    Location
    new york
    Posts
    325
    Thanks
    210
    Thanked 16 Times in 14 Posts

    Default MEP-802a electrical diagram

    I looked at every TM and can't find a good electrical diagram for it. I'm trying to figure out what wires do what on the master switch. Thanks for any help!

  2. #2
    4 Star General glassk's Avatar
    Join Date
    Dec 2011
    Location
    Hampton, GA
    Posts
    1,004
    Thanks
    263
    Thanked 358 Times in 247 Posts

    Default

    2-47. MASTER SWITCH
    Testing.Shut down generator set.Open left side engine access door and disconnect negative battery cable.Release control panel by turning two fasteners and lower control panel slowly.Tag and disconnect MASTER SWITCH (42, Figure 2-14) electrical leads.Check switch for continuity using multimeter. Refer to Electrical Schematic FO-1 (S-1 Circuit Schedule) todetermine circuits made to corresponding switch positions.Check continuity until all five positions have been checked.door

    ARMY TM 9-6115-641-24
    AIR FORCE TO 35C2-3-456-12
    12 Volt Trailer Wire & 24 volt Electrical Tape GROVE SM31AS Maintenance Platform M60 60 amp Dist. Box
    M116A1, Mep002A MEP 026D,Fluke 51 K/J Themometer,M116A ,Rothco Military 100 Mph Cloth Duct Tape ,

  3. #3
    4 Star General glassk's Avatar
    Join Date
    Dec 2011
    Location
    Hampton, GA
    Posts
    1,004
    Thanks
    263
    Thanked 358 Times in 247 Posts
    12 Volt Trailer Wire & 24 volt Electrical Tape GROVE SM31AS Maintenance Platform M60 60 amp Dist. Box
    M116A1, Mep002A MEP 026D,Fluke 51 K/J Themometer,M116A ,Rothco Military 100 Mph Cloth Duct Tape ,

  4. #4
    Colonel
    Join Date
    Feb 2013
    Location
    new york
    Posts
    325
    Thanks
    210
    Thanked 16 Times in 14 Posts

    Default

    I saw that what I can't seem to
    Find is...
    "Electrical Schematic FO-1 (S-1 Circuit Schedule)"

  5. #5
    4 Star General Steel Soldiers Vendor m-35tom's Avatar
    Join Date
    May 2007
    Location
    eldersburg maryland
    Posts
    2,751
    Thanks
    105
    Thanked 577 Times in 367 Posts

    Default

    Quote Originally Posted by CDR View Post
    I saw that what I can't seem to
    Find is...
    "Electrical Schematic FO-1 (S-1 Circuit Schedule)"
    did you find it? it is right after ALPHABETICAL INDEX near the end of the -24 manual. S-1 is really very simple, it is just 4 single pole single throw switches with one end of each tied together.
    Last edited by m-35tom; 04-02-2014 at 23:59.
    tom bauer m-621
    air conditioned - 28 air
    6 wheel drive - 3 air lockers
    power steering - hydraulic - over 250 kits sold
    fast - now 1 of 43 with .69 od !!!
    m-35 transmission expert
    avatar - 64mph @ 2400 rpm with 14.5R20XL

  6. The Following User Says Thank You to m-35tom For This Useful Post:

    CDR (04-03-2014)

  7. #6
    Colonel
    Join Date
    Feb 2013
    Location
    new york
    Posts
    325
    Thanks
    210
    Thanked 16 Times in 14 Posts

    Default

    Never found let me check that out thanks

  8. #7
    Colonel
    Join Date
    Feb 2013
    Location
    new york
    Posts
    325
    Thanks
    210
    Thanked 16 Times in 14 Posts

    Default

    Ok I looked maybe I'm blind last thing looks like the hall sensor
    ImageUploadedByTapatalk1396527636.167701.jpg

  9. #8
    4 Star General glassk's Avatar
    Join Date
    Dec 2011
    Location
    Hampton, GA
    Posts
    1,004
    Thanks
    263
    Thanked 358 Times in 247 Posts

    Default

    page 279.JPG

    page 279
    12 Volt Trailer Wire & 24 volt Electrical Tape GROVE SM31AS Maintenance Platform M60 60 amp Dist. Box
    M116A1, Mep002A MEP 026D,Fluke 51 K/J Themometer,M116A ,Rothco Military 100 Mph Cloth Duct Tape ,

  10. The Following User Says Thank You to glassk For This Useful Post:

    CDR (04-03-2014)

  11. #9
    4 Star General Steel Soldiers Vendor m-35tom's Avatar
    Join Date
    May 2007
    Location
    eldersburg maryland
    Posts
    2,751
    Thanks
    105
    Thanked 577 Times in 367 Posts

    Default

    yep, upper right is S-1 pin out. actual wiring is on left side of that same page. i could not find a page number in my manual!
    tom bauer m-621
    air conditioned - 28 air
    6 wheel drive - 3 air lockers
    power steering - hydraulic - over 250 kits sold
    fast - now 1 of 43 with .69 od !!!
    m-35 transmission expert
    avatar - 64mph @ 2400 rpm with 14.5R20XL

  12. The Following User Says Thank You to m-35tom For This Useful Post:

    glassk (04-03-2014)

  13. #10
    Colonel
    Join Date
    Feb 2013
    Location
    new york
    Posts
    325
    Thanks
    210
    Thanked 16 Times in 14 Posts

    Default

    This it great thank you!

Similar Threads

  1. M101A1 standard electrical plug pin diagram?
    By hepheastus2003 in forum Trailers
    Replies: 4
    Last Post: 12-30-2010, 10:58
  2. mep-802a
    By dogkiller in forum Generators
    Replies: 1
    Last Post: 04-30-2010, 14:49
  3. Need electrical diagram
    By renoenvy08 in forum Electrical
    Replies: 1
    Last Post: 12-01-2008, 18:49
  4. M38A1 Electrical Wiring Diagram
    By wachtelj in forum M38, M38A1 and M170
    Replies: 5
    Last Post: 11-03-2007, 00:09
  5. Electrical Diagram
    By JRBAMATEX in forum The Deuce
    Replies: 4
    Last Post: 12-23-2006, 21:49

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •