Recent content by Ttchutch

When I originally pulled the transmission out a few months ago the plug has some fluid in it. It was the original plug. I have no idea if the new plug was leaking or not because I dropped the truck off at the shop as I lost reverse and overdrive. Apparently they're going to warranty the...

The wire harness has already been changed out to the '94 on harness.

I bought the Suburban with a bad 6.2 already in it. So I ordered a used military 6.2 from White Owl and swapped them out. I installed the TPS from the old motor and changed everything from 24v to 12v. I drove the Suburban for about 3 years and then I started having what I thought was engine...

They are going to warranty the transmission. I have thought about taking the truck to another shop but, the truck is 2 hours away from me. I'm in a small town.

I meant $1000 or less for the controller with installation.

I'm not sure if this is the place to post this issue.I've got a '91 GMC Suburban V2500 4x4 with a military 6.2l diesel. This Suburban has the 4l80E transmission in it. The transmission went out a few months ago so I pulled it, had it rebuilt and reinstalled it. Then about 3 weeks ago the...

Changed the fuel filter about a 1000 miles ago and then again over this weekend when the problems became worse. Changing the fuel filter had no effect.

What is the governor weight retainer ring?

Both sides getting clogged at the same time would be near to impossible. I think I'll still pull the pipes off just to check because it's easy....and who knows. Should I upload a video of what it's doing?

I have thought of that too. In a couple days I'll pull the exhaust off the manifolds and see if it runs better. I changed the mufflers about 15,000 miles ago but who knows.

I've been looking at some remanufactured pumps online. Did the military 6.2 use the same pump as the civilian engine?

I'm new to the forum. I hope I put this in the correct thread. I've got a 91 Suburban 2500 with a Humvee 6.2 diesel in it. I've put over 70,000 miles on the motor and it has always ran great. It has just recently lost power. I've changed the fuel filter, air filter and used some BG fuel injector...